compressive strength of m25 concrete by using quarry dust

your location:

Cases Center

compressive strength of m25 concrete by using quarry dust

compressive strength of m25 concrete by using quarry dust

compressive strength of m25 concrete by using quarry dust

(PDF) Study on Performance of Quarry Dust as Fine

2018-3-7  The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%,

get price

Analysis of Concrete Made from Quarry Dust IJERT

2019-7-1  analysis, the experiment work is performed by using cement, fine aggregate, coarse aggregate, quarry dust. The examples were casted for M25 grade of concrete by supplanting the cement 0%, 5%, 10%, 15% and 20% by quarry dust and tested for workability by slump test, compressive strength, flexure strength and split tensile test

get price

STUDY ON PERFORMANCE OF QUARRY DUST AS FINE

2018-3-20  strength and also a decrease in workability with increasing quarry dust content. EXPERIMENTAL PROGRAMME The present work investigates the effect of using quarry dust as partial replacement for sand on the compressive strength and splitting tensile strength for M25 grade concrete. It

get price

Use of Quarry Dust to Replace Sand in Concrete An

2021-6-4  strength of concrete when replacing sand by quarry dust from 0% to 100% in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were obtained at room temperature. Also the temperature

get price

Experimental Investigation on Quarry Dust and Recycled

2019-6-6  3. The compressive strength at the end of 28 days steadily decreases when the RA percentage is increased. However the compressive strength of M25 concrete at the end of 28 days for 30% replacement of RA and 20% of Quarry dust is 39 N/mm2 as shown in Table -8. 4. The compressive strength showed a steep decrease when the RA percentage is

get price

PARTIAL REPLACEMENT OF SAND BY QUARRY DUST IN

2017-5-27  compressive strength of M20 and M25 grades of concrete on partial replacement of sand by Quarry dust by 20%, 30%, 40% and 50%. The compressive strength of concrete cubes are obtained after 7 and 28 days of curing. This experimental study shows that the concrete made with quarry dust might

get price

Stone Dust in Concrete: Effect on Compressive Strength

2017-8-24  the workability and compressive strength of concrete made using stone dust as partial replacement of fine aggregate in the range of 10% 100%. M25 grade of concrete was designed using Portland pozzolana cement (PPC) for referral concrete. Workability and Compressive strength

get price

Research Article Study on Compressive Strength of

2019-7-30  replaced concrete. For % quarry dust concrete workability is . and for % replacement of quarry dust concrete . compacting factor was observed. (d) e compressive strength results of quarry dust concrete (cubes) were obtained in the fourth series, where M, M, and M grades of concrete with,, and

get price

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND

2020-10-15  Quarry Rock Dust as 100% substitutes for Natural Sand in concrete. Mix design has been developed for M25 and M40 grades using design approach IS for both conventional concrete and quarry dust concrete. Tests were conducted on cubes and beams to study the strength of concrete made of Quarry Rock Dust

get price

Experimental Study on The Strength of Concrete using

2016-6-29  fine aggregate by using the quarry dust and the waste marble dust in the concrete. In this process the natural sand were concrete was M25 grade of concrete. The specimens were grades The classification is mainly based on the compressive strength of

get price

(PDF) Study on Performance of Quarry Dust as

2018-3-7  Method of curing by ponding was adopted and the compressive strength of quarry-dust-iron-filings-blended concrete with varying materials proportions of 12.5%, 25%, 37.5% and 50% at 28days of

get price

Experimental Investigation on Quarry Dust and Recycled

2019-6-6  3. The compressive strength at the end of 28 days steadily decreases when the RA percentage is increased. However the compressive strength of M25 concrete at the end of 28 days for 30% replacement of RA and 20% of Quarry dust is 39 N/mm2 as shown in Table -8. 4. The compressive strength showed a steep decrease when the RA percentage is

get price

PARTIAL REPLACEMENT OF SAND BY QUARRY DUST IN

2017-5-27  compressive strength of M20 and M25 grades of concrete on partial replacement of sand by Quarry dust by 20%, 30%, 40% and 50%. The compressive strength of concrete cubes are obtained after 7 and 28 days of curing. This experimental study shows that the concrete made with quarry dust might

get price

An Experimental Study on Quarry Dust as a Fine

2019-4-11  the quarry dust. 3. The compressive strength and split tensile strength of concrete for grade M30 with quarry dust as fine aggregate were found to be comparable with the concrete made with the river bed sand. 4. The increase in compressive strength

get price

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND

2020-10-15  Quarry Rock Dust as 100% substitutes for Natural Sand in concrete. Mix design has been developed for M25 and M40 grades using design approach IS for both conventional concrete and quarry dust concrete. Tests were conducted on cubes and beams to study the strength of concrete made of Quarry Rock Dust

get price

IMPACT OF QUARRY DUST & DOLOMITE POWDER ON

2018-6-20  ABSTRACT-The purpose of this work is to describe the effect of quarry dust and dolomite on the compressive strength of concrete. The present examinations indicate that dolomite may be used as partial replacement of cement in concrete and quarry dust may be suitably replaced with fine aggregate in concrete to some extent.

get price

Experimental Investigations on by using Quarry Dust

2017-9-26  of cement with quarry dust proportions of 0%, 10%, 20% and 30% by weight of cement. Immersion test of sulphuric acid and hydrochloric acid are conducted at 5% by volume of water. past is that too much emphasis is placed on concrete Keywords: Concrete, Quarry dust, Fly Ash, Fine Aggregate, Compressive Strength, sulphuric acid and

get price

The Utilization of Quarry Dust as Fine Aggregates in

75% & 100% in concrete & cubes were casted using this concrete containing quarry dust. The compressive strength of these cubes were tested after 7 days, 21 days & 28 days & the results thus obtained were compared to the compressive strength of the cubes made up of conventional concrete containing no quarry dust. 5 Results and Discussions

get price

A STUDY OF COMPRESSIVE STRENGTH OF CONCRETE

2007-7-19  examining of quarry dust to replace sand in concrete by using the water-cement ratio of 0.45 the average compressive strength of concrete specimens at 28 days is 323.36 ksc. The arisen problem during the mixing process of concrete by using quarry dust to

get price

Compressive Strength Of Concrete While Use Quarry Dust

compressive strength of m25 concrete by using quarry dust. TON crushing equipment is designed to achieve maximum productivity and high reduction ratio. From large primary jaw crusher and impact crusher to cone crusher and

get price

Experimental Investigation on Quarry Dust and Recycled

2019-6-6  3. The compressive strength at the end of 28 days steadily decreases when the RA percentage is increased. However the compressive strength of M25 concrete at the end of 28 days for 30% replacement of RA and 20% of Quarry dust is 39 N/mm2 as shown in Table -8. 4. The compressive strength showed a steep decrease when the RA percentage is

get price

IMPACT OF QUARRY DUST & DOLOMITE POWDER ON

2018-6-20  ABSTRACT-The purpose of this work is to describe the effect of quarry dust and dolomite on the compressive strength of concrete. The present examinations indicate that dolomite may be used as partial replacement of cement in concrete and quarry dust may be suitably replaced with fine aggregate in concrete to some extent.

get price

m25 concrete mix using quarry dust as fine

2013-6-3  Structural properties of concrete containing lateritic sand and quarry . of lateritic sand and quarry dust from 0% to in steps of 25%.The samples were tested at

get price

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND

2020-10-15  Quarry Rock Dust as 100% substitutes for Natural Sand in concrete. Mix design has been developed for M25 and M40 grades using design approach IS for both conventional concrete and quarry dust concrete. Tests were conducted on cubes and beams to study the strength of concrete made of Quarry Rock Dust

get price

Influence of Quarry Dust on Compressive Strength of

Objectives: In the present study, by-product of stone crushed, quarry dust is replaced as a fine aggregate with 20%, 30%, 40%, 50% replacement.Methods/Analysis: The fine aggregate is being replaced with fine aggregate and the compressive strength is determined for the concrete by testing the sample cube. The properties such as the specific gravity, fineness modulus, moisture content etc. are

get price

An Experimental Study on Quarry Dust as a Fine

2019-4-11  An Experimental Study on Quarry Dust as a Fine Aggregate for Making a Concrete. D. Sathyapriya 1, G. Alagar Raja 2, K. Raguram 3, S. Elayabarathi 4, M. Arunkumar 5 Asst professor 1Dept of Civil Engineering, Sri Rangathar Institute of Engg and Tech, Coimbatore, Tamilnadu. UG Student 2,3,4,5 Dept of Civil Engineering, Sri Rangathar Institute of Engg and Tech, Coimbatore, Tamilnadu.

get price

Experimental Investigations on by using Quarry Dust

2017-9-26  of cement with quarry dust proportions of 0%, 10%, 20% and 30% by weight of cement. Immersion test of sulphuric acid and hydrochloric acid are conducted at 5% by volume of water. past is that too much emphasis is placed on concrete Keywords: Concrete, Quarry dust, Fly Ash, Fine Aggregate, Compressive Strength, sulphuric acid and

get price

[PDF] COMPRESSIVE STRENGTH OF CONCRETE USING

Samples of concrete (eg. cubes) were made using varying contents of laterite and quarry dust as fine aggregate. The quantity of laterite was varied from 0% to 100% against quarry dust at intervals of 25%. The samples were cured for specified periods and tested in the laboratory for compressive strength.

get price

A STUDY OF COMPRESSIVE STRENGTH OF CONCRETE

2007-7-19  examining of quarry dust to replace sand in concrete by using the water-cement ratio of 0.45 the average compressive strength of concrete specimens at 28 days is 323.36 ksc. The arisen problem during the mixing process of concrete by using quarry dust to

get price